Influence of pH Buffer and Oxygen Concentration in Flue Gas on the System of Flue Gas Desulfurization with Pyrolusite Pulp

您当前的位置：

首页 >

文章列表页 >

Influence of pH Buffer and Oxygen Concentration in Flue Gas on the System of Flue Gas Desulfurization with Pyrolusite Pulp

更新时间：2023-11-28

- Influence of pH Buffer and Oxygen Concentration in Flue Gas on the System of Flue Gas Desulfurization with Pyrolusite Pulp
- Advanced Engineering Sciences Vol. 39, Issue 4, Pages: 73-78(2007)
- 作者机构：
- 作者简介：
- 基金信息：
- DOI：
  CLC：
- Published：2007，
扫描看全文
孙峻,苏仕军,丁桑岚.pH值缓冲剂及烟气氧含量对软锰矿浆烟气脱硫体系的影响[J].工程科学与技术,2007,39(4):73-78.

Influence of pH Buffer and Oxygen Concentration in Flue Gas on the System of Flue Gas Desulfurization with Pyrolusite Pulp. [J]. Advanced Engineering Sciences 39(4):73-78(2007)
孙峻,苏仕军,丁桑岚.pH值缓冲剂及烟气氧含量对软锰矿浆烟气脱硫体系的影响[J].工程科学与技术,2007,39(4):73-78. DOI：

Influence of pH Buffer and Oxygen Concentration in Flue Gas on the System of Flue Gas Desulfurization with Pyrolusite Pulp. [J]. Advanced Engineering Sciences 39(4):73-78(2007) DOI：

摘要

中文摘要: 软锰矿浆烟气脱硫工艺能利用软锰矿中的MnO2与烟气中的SO2反应生成副产品硫酸锰，喷射鼓泡反应器(JBR)适宜于该工艺体系，但在单级JBR反应器中进行软锰矿浆烟气脱硫很难同时实现较高的脱硫率(η(SO2))和锰浸出率(X(Mn))。针对这一问题，通过实验在JBR反应器中考察了pH值缓冲剂添加比例和烟气氧含量对软锰矿浆烟气脱硫体系的影响，确定烟气氧含量为21%时pH值缓冲剂的最佳添加比例为30%，烟气氧含量为7%时pH缓冲剂的最佳添加比例为10%。结果表明，在模拟燃煤烟气的条件下，体系中pH值缓冲剂的添加比

Abstract

Abstract:The flue gas desulfurization with pyrolusite pulp can produce the byproduct of manganese sulfate from the corresponding chemical reaction between MnO2 in pyrolusite and SO2 in flue gas

and moreover

Jet bubbling reactor（JBR）is the reactor that fits this technique very well. However

it is difficult to achieve the goal to obtain high enough SO2 absorption efficiency and Mn2+ extraction rate simultaneously in a single JBR. Thereafter

some research work about the effect of additive percentage of pH value buffer solution and oxygen concentration in flue gas on this system of flue gas desulfurization with pyrolusite pulp in a single JBR was carried out

and it was illustrated that the optimized additive percentage of pH value buffer was 30% and 10% when oxygen concentration in flue gas is 21% and 7% respectively. Based on the experiment results

it was proved that under the conditions of simulated flue gas from real flaming coal

if the additive percentage of pH buffer value was 10%

the SO2 absorption efficiency and Mn2+ extraction rate could both reach above 80% in a single JBR. Wherefore

it could be concluded that this technique of flue gas desulfurization is not only operationally but also commercially feasible

and also

promising in industrial application in the future.

关键词

软锰矿烟气脱硫pH值缓冲剂烟气氧含量

Keywords

pyrolusite pulpflue gas desulfurizationpH value bufferoxygen concentration of flue gas

references

Su Shijun,Zhu Xiaofan,Liu Yongjun,et al.A pilot scale jet bubbling reactor for wet flue gas desulfurization with pyrolusite[J].Journal of Environmental Science,2005,17(5):827-831.

Sun Shili,Zhu Xiaofan,Su Shijun,et al.Flue gas desulfurization in jet bubble reactor[J].Environmental Protection of Chemical Industry,2005,25(4):323-326.[孙世利,朱晓帆,苏仕军,等.用喷射鼓泡反应器进行烟气脱硫[J].化工环保,2005,25(4):323-326.]

Zhu Xiaofan,Liu Ruobin,Jiang Wenju,et al.Effect of agitation rate on the reaction of removal with pyrolusite pulp[J].Environmental Engineering,2003,21(1):47-49.[朱晓帆,刘若冰,蒋文举,等.喷射鼓泡反应器在软锰矿烟气脱硫中的应用[J].环境工程,2003,21(1):47-49.]

Zhu Xiaofan,Jiang Wenju,Su Shijun,et al.The study of reaction mechanism desulfurization in flue gas with pyrolusite pulp.[J].Techniques and Equipment for Environmental Pollution Control,2002,3(3):44-46.[朱晓帆,蒋文举,苏仕军等.软锰矿浆烟气脱硫反应机理研究[J].环境污染治理与设备,2002,3(3):44-46.]

Zhu Xiaofan,Su Shijun,Ren Zhiling,et al.Study on flue gas desulfurization with pyrolusite pulp[J].Journal of Sichuan University:Engineering Science Edition,2000,32(5):36-39.[朱晓帆,苏仕军,任志凌,等.软锰矿烟气脱硫研究[J].四川大学学报:工程科学版,2000,32(5):36-39.]

Han Xiaozhao,Zhu yanfang,Yao Weitang,et al.Preparation of manganse sulfate from pyrolusite by absorpting sulfur dioxide(I)[J].Ming and Metallurgical Engineering,2003,23(2):53-55.[韩效钊,朱艳芳,姚卫堂,等.软锰矿吸收SO2制备硫酸锰(I)[J].矿冶工程,2003,23(2):53-55.]

Li Junqi,Shi Lianjun,Jin Huixin,et al.Study on producing manganese sulfate with pyrolusite absorbed industry waste-gas SO2[J].Journal of Guizhou University of Technology:Natural Science Edition,2003,32(5):4-8.[李军旗,史连军,金会心等.软锰矿吸收SO2气体制取硫酸锰的实验研究[J].贵州工业大学学报:自然科学版,2003,32(5):4-8.]

Fu Jiangang,Mao Yaoqing,Zhong Hong.Study on removal of SO2 with pyrolusite[J].China\'s Manganese Industry,2003,21(1):19-22.[符剑刚,毛耀清,钟宏.软锰矿湿法脱硫工艺的研究[J].中国锰业,2003,21(1):19-22.]

Wang Zhijun,Tong Zhiquan.Flue gas desulfurization by pyrolusite slurry in orifice column[J].Natural Science Journal of Xiangtan University,1999,21(4):78-82.[王治军,童志权.用软锰矿浆在筛板塔中烟气脱硫[J].湘潭大学自然科学学报,1999,21(4):78-82.]

Huang Yan,Wang Zhijun.Study on removal of SO2 with pyrolusite pulp[J].Environmental Engineering,1998,16(4):43-46.[黄妍,王治军.软锰矿浆脱除烟气中SO2的研究[J].环境工程,1998,16(4):43-46.]

Chen Zhaoqiong,Tong Zhiquan.Approach a mechanism of flue gas desulfurization with pyrolusite slurry and strengthen the Process[J].Natural Science Journal of Xiangtan University,1998,20(3):112-116.[陈昭琼,童志权.软锰矿浆烟气脱硫过程机理探讨及过程强化[J].湘潭大学自然科学学报,1998,20(3):112-116.]

更多指标>

Views

下载量

CNKI被引量

Alert me when the article has been cited

提交

Tools

Publicity Resources

Modeling for the Absorption of SO2 in Ｆlue Gas with Landfill Leachate Coupled with Desorption of Ammonia

Desulfurization on Surface Modified Activated Carbon Fibers with Nitrogen-containing Group

Related Author

No data

Related Institution

四川大学环境科学与工程系

国家烟气脱硫工程技术研究中心四川大学环境工程系

四川大学化工学院四川

四川大学建筑与环境学院

国家烟气脱硫工程技术研究中心

⁰